BIODIESEL PRODUCTION FROM WASTE FISH CANNING OIL USING COCOPEAT ASH CATALYST

Siti Diah Ayu Febriani, Prisca Amalia Nofitasari, Saiful Anwar

Abstract


Biodiesel is an environmentally friendly alternative fuel for diesel engines. The research studies the extraction process of biodiesel from waste produced by a fish canning factory using a heterogeneous catalyst known as cocopeat ash. The experiment was designed utilizing a completely randomized design with two factorial treatments and four repetitions. The primary factor under investigation was the composition of the catalyst, specifically 3%, 5%, and 7% w/v methanol. The second factor examined was the reaction time of either 60 minutes or 120 minutes. Data analysis revealed variations in density, viscosity, acid number, and Free Fatty Acids (FFA) in fish oil before and after refinement. The treatment that yielded the highest results was A3B2, featuring a catalyst composition of 7% and a reaction time duration of two hours, which achieved an impressive biodiesel yield of 81%. Moreover, several parameters tested for compliance with SNI-04-7182-2015 standards showed positive outcomes. These parameters include a density value measuring 876.3 kg/m³, the flash point around 160°C, iodine number reaching 16.36 g/100g, and heating value 47.47 MJ/Kg.


Keywords


Biodiesel; Composite Catalyst; Reaction Time; Cocopeat Ash; Waste Fish Oil

Full Text:

PDF

References


Helwani, Z., Othman, M.R., Aziz, N. & Fernando, W. J. N. (2009). Solid heterogeneous catalysts for transesterification of triglycerides with methanol: a review. Applied Catalysis A: General, 363(1–2), 1-10.

Nurdini, D. A. (2008). Desain proses pembuatan biodiesel dari bahan baku minyak jelantah dengan katalis alami abu cocopeat [Thesis]. Institut Teknologi Bandung.

Agustian, E., Praptijianto, A., Sebayang, D., Rus, A.Z.M. and Hasan, A. (2016). Biodiesel Production from waste cooking oil by using ultrasonic Tubular Reactor. Int. J. Innov. Mech. Eng. Adv. Mater, 2(1), 31-38.

Astutik, F. E. M. (2014). Penggunaan Abu Batang Pisang Sebagai Katalis Basa Heterogen Dalam Rreaksi Transesterifikasi Minyak Goreng Bekas Pada Proses Pembuatan Biodiesel [Thesis]. Politeknik Negeri Jember.

Helwani, Z., Othman, M.R., Aziz, N. & Fernando, W. J. N. (2009). Solid heterogeneous catalysts for transesterification of triglycerides with methanol: a review. Applied Catalysis A: General, 363(1–2), 1-10.

Manullang, W. F. (2016). 1,2 -dimetil-1, 2,2-tetrafeildisilana sulfonat sebagai katalis reaksi transesterifikasi CPO (Crude Palm Oil) berkadar asam lemak bebas tinggi untuk menghasilkan biodiesel [Thesis]. Universitas Sumatera Utara

Syarif, M. (2016). Calcium Carbide Residue (CCR) sebagai katalis basa heterogen pada reaksi transesterifikasi minyak kesambi (Schleichera Oleosa L.) [Thesis]. Politeknik Negeri Jember.

Prihandana R., Hendroko R. & Nuramin M. (2006). Menghasilkan biodiesel murah mengatasi polusi dan kelangkaan BBM. PT. Agromedia Pustaka.

Padil, Wahyuningsih, S., & Awaluddin, A. (2010). Pembuatan biodiesel dari minyak kelapa melalui reaksi metanolisis menggunakan katalis CaCO3 yang dipijarkan”. Jurnal Natur Indonesia, 13(1), 27-32.

Badan Pusat Statistik. (2015). Statistik Transportasi Darat 2015.

Demirbas, A. (1998). Combustion properties and calculation of higher heating values of diesel fuels. Petroleum Science and Technology, 6(7-8), 785-795.

Gracia-Moreno, P.J., Khanum, M., Guadix, A. & Guadix, E.M. (2014). Optimization of biodiesel production from waste fish oil. Renewable Energy, 68, 618-624

Indartono, Y.S. (2006). Mengenal biodiesel : karakterisrik, produksi, hingga performansi mesin (2). Berita Iptek Cyber Media.

Santoso, H., Kristianto, I., & Setyadi, A. (2013). Pembuatan biodiesel menggunakan katalis basa heterogen berbahan dasar kulit telur [Final report]. Universitas Katolik Parahayangan.

Azad, S. A., Wuen, L. Y., Tamrin, M. (2019). Potential of fish wastes as feedstock for biodiesel. Advances in Bioscience and Biotechnology, 10, 109-118.




DOI: http://dx.doi.org/10.22441/ijimeam.v5i1.19936

Refbacks

  • There are currently no refbacks.


Copyright (c) 2023 Siti Diah Ayu Febriani, Prisca Amalia Nofitasari, Saiful Anwar

Creative Commons License
This work is licensed under a Creative Commons Attribution-ShareAlike 4.0 International License.

INDEXED IN

 

Publisher Address:
Universitas Mercu Buana
Program Studi S2 Teknik Mesin
Jl. Meruya Selatan No. 1, Jakarta 11650, Indonesia
Phone/Fax. (+6221) 5871335
Email [email protected]
Homepage http://teknikmesin.ft.mercubuana.ac.id/

Creative Commons License
This work is licensed under a Creative Commons Attribution-ShareAlike 4.0 International License.